Whirlpool Gas Cooktop 30 In. (WCGK5030PB) installation instructions

Contents

1. COOKTOP SAFETYp. 2

   Your safety and the safety of others are very important. We have provided many important safety messages in this manual and on your appliance. Always read and…

2. Cooktop Safetyp. 2
3. COOKTOP MAINTENANCE AND CAREp. 4

   General Cleaning IMPORTANT: Before cleaning, make sure all controls are off and the cooktop is cool. Always follow label instructions on cleaning products.…

4. General Cleaningp. 4

   IMPORTANT: Before cleaning, make sure all controls are off and the cooktop is cool. Always follow label instructions on cleaning products. Soap, water, and a…

5. INSTALLATION INSTRUCTIONSp. 5
6. REQUIREMENTSp. 5

   Tools and Parts Tools Needed n Tape measure n Flat-blade screwdriver n Phillips screwdriver n 15/16" (24 mm) combination wrench n Pipe wrench n Wrench or…

7. Tools and Partsp. 5

   Tools Needed n Tape measure n Flat-blade screwdriver n Phillips screwdriver n 15/16" (24 mm) combination wrench n Pipe wrench n Wrench or pliers n Marker or…

8. Location Requirementsp. 6

   IMPORTANT: Observe all governing codes and ordinances. Do not obstruct flow of combustion and ventilation air. n It is the installer’s responsibility to comply…

9. Electrical Requirementsp. 7

   WARNING Electrical Shock Hazard Plug into a grounded 3 prong outlet. Do not remove ground prong. Do not use an adapter. Do not use an extension cord. Failure…

10. Gas Supply Requirementsp. 7

    WARNING Explosion Hazard Use a new CSA International approved gas supply line. Install a shut-off valve. Securely tighten all gas connections. If connected to…

11. INSTALLATIONp. 8

    Install Cooktop WARNING Excessive Weight Hazard Use two or more people to move and install or uninstall appliance. Failure to do so can result in back or other…

12. Install Cooktopp. 8

    WARNING Excessive Weight Hazard Use two or more people to move and install or uninstall appliance. Failure to do so can result in back or other injury. Decide…

13. Make Gas Connectionp. 9
14. Complete Installationp. 11

    Electronic Ignition System Initial lighting and gas flame adjustments Surface burners use electronic igniters in place of standing pilots. When the cooktop…

15. GAS CONVERSIONSp. 11

    IMPORTANT: Gas conversions from Natural gas to Propane gas must be done by a qualified installer. Before proceeding with conversion, shut off the gas supply to…

16. Convert from Natural Gas to Propane Gasp. 12

    1. Turn manual shut-off valve to the closed position. A B C A. To cooktop B. Shut-off valve (closed position) C. Gas supply line 2. Unplug cooktop or…

17. Convert from Propane Gas to Natural Gasp. 14
18. Lighting the Electronic Ignitersp. 16

    The cooktop burners use electronic igniters in place of standing pilots. When the cooktop control knob is pushed in and turned to Ignite, the system creates a…

19. Low Flame Height Adjustmentp. 16

    Each burner flame has been factory set to the lowest position available to provide reliable and constant reignition of the burner. However, each burner can be…

20. Complete Burner Adjustmentp. 17

    1. Check burner flame(s) for proper size and shape. The cooktop low burner flame should be a steady blue flame approximately 1/4" (6.4 mm) high. A. Low flame…

21. Moving the Cooktopp. 17

    WARNING Electrical Shock Hazard Disconnect power before servicing. Failure to do so can result in death or electrical shock. WARNING Explosion Hazard Use a new…

22. SÉCURITÉ DE LA TABLE DE CUISSONp. 18

    Votre sécurité et celle des autres sont très importantes. Nous donnons de nombreux messages de sécurité importants dans ce manuel et sur votre appareil.…

23. Sécurité de la table de cuissonp. 18
24. ENTRETIEN ET RÉPARATION DE LA TABLE DE CUISSONp. 21

    Nettoyage général IMPORTANT : Avant le nettoyage, s’assurer que toutes les commandes sont désactivées et que le four est froid. Toujours suivre les…

25. Nettoyage généralp. 21

    IMPORTANT : Avant le nettoyage, s’assurer que toutes les commandes sont désactivées et que le four est froid. Toujours suivre les instructions figurant sur les…

26. INSTRUCTIONS D’INSTALLATIONp. 22
27. SPÉCIFICATIONSp. 22

    Outils et pièces Outils nécessaires n Ruban à mesurer n Tournevis à tête plate n Tournevis à tête cruciforme n Clé mixte de 15/16 po (24 mm) n Clé à tuyauterie…

28. Outils et piècesp. 22

    Outils nécessaires n Ruban à mesurer n Tournevis à tête plate n Tournevis à tête cruciforme n Clé mixte de 15/16 po (24 mm) n Clé à tuyauterie n Clé ou pince n…

29. Exigences d’emplacementp. 23

    IMPORTANT : Observer les dispositions de tous les codes et règlements en vigueur. Ne pas obstruer le flux de combustion et de ventilation. n C’est à…

30. Spécifications électriquesp. 24

    AVERTISSEMENT Risque de décharge électrique Brancher l’appareil sur une prise à 3 alvéoles reliée à la terre. Ne pas enlever la prise de liaison à la terre. Ne…

Other documents for this model

• Whirlpool Gas Cooktop 30 In. (WCGK5030PB) quick start guide