KitchenAid Cooktop Gas On Glass 30 Inch (KCGG530PBL) installation instructions

Contents

1. COOKTOP SAFETYp. 2

   Your safety and the safety of others are very important. We have provided many important safety messages in this manual and on your appliance. Always read and…

2. Cooktop Safetyp. 2
3. COOKTOP MAINTENANCE AND CAREp. 4

   General Cleaning IMPORTANT: Before cleaning, make sure all controls are off and the cooktop is cool. Always follow label instructions on cleaning products.…

4. General Cleaningp. 4

   IMPORTANT: Before cleaning, make sure all controls are off and the cooktop is cool. Always follow label instructions on cleaning products. Soap, water, and a…

5. INSTALLATION INSTRUCTIONSp. 5
6. REQUIREMENTSp. 5

   Tools and Parts Gather the required tools and parts before starting installation. Tools Needed n Tape measure n Screwdriver n 15/16" (24 mm) combination wrench…

7. Tools and Partsp. 5

   Gather the required tools and parts before starting installation. Tools Needed n Tape measure n Screwdriver n 15/16" (24 mm) combination wrench n Pipe wrench n…

8. Location Requirementsp. 6

   IMPORTANT: Observe all governing codes and ordinances. Do not obstruct flow of combustion and ventilation air. n It is the installer’s responsibility to comply…

9. Electrical Requirementsp. 7

   WARNING Electrical Shock Hazard Plug into a grounded 3 prong outlet. Do not remove ground prong. Do not use an adapter. Do not use an extension cord. Failure…

10. Gas Supply Requirementsp. 7

    WARNING Explosion Hazard Use a new CSA International approved gas supply line. Install a shut-off valve. Securely tighten all gas connections. If connected to…

11. INSTALLATIONp. 8

    Prepare Cooktop for Installation WARNING Excessive Weight Hazard Use two or more people to move and install or uninstall appliance. Failure to do so can result…

12. Prepare Cooktop for Installationp. 8

    WARNING Excessive Weight Hazard Use two or more people to move and install or uninstall appliance. Failure to do so can result in back or other injury. Decide…

13. Install Cooktopp. 9

    Style 1: Cooktop over undercounter built-in oven IMPORTANT: Clamping brackets should not be used. 1. Using two or more people, place cooktop right side up into…

14. Make Gas Connectionp. 10
15. Attach Cooktop to Countertopp. 11

    NOTE: This section applies only if you are using clamping brackets. D A. Glass cooktop B. Cooktop base C. Attachment screw D. Clamping bracket (extends far…

16. Complete Installationp. 11

    Electronic Ignition System Initial lighting and gas flame adjustments Surface burners use electronic igniters in place of standing pilots. When the cooktop…

17. GAS CONVERSIONSp. 12

    High Altitude Conversion To convert the cooktop for elevations above 6,560 ft (1999.5 m), order a High Altitude Conversion Kit. To order, see the Online…

18. Convert from Natural Gas to Propane Gasp. 12

    1. Turn manual shut-off valve to the closed position. A B C A. To cooktop B. Shut-off valve (closed position) C. Gas supply line 2. Unplug cooktop or…

19. Convert from Propane Gas to Natural Gasp. 14
20. Lighting the Electronic Ignitersp. 16

    The cooktop burners use electronic igniters in place of standing pilots. When the cooktop control knob is pushed in and turned to , the system creates a spark…

21. Low Flame Height Adjustmentp. 16

    Each burner flame has been factory set to the lowest position available to provide reliable and constant reignition of the burner. However, each burner can be…

22. Complete Burner Adjustmentp. 17

    1. Check burner flame(s) for proper size and shape. The cooktop low burner flame should be a steady blue flame approximately 1/4" (6.4 mm) high. A. Low flame…

23. Moving the Cooktopp. 17

    WARNING Electrical Shock Hazard Disconnect power before servicing. Failure to do so can result in death or electrical shock. WARNING Explosion Hazard Use a new…

24. SÉCURITÉ DE LA TABLE DE CUISSONp. 18

    Votre sécurité et celle des autres sont très importantes. Nous donnons de nombreux messages de sécurité importants dans ce manuel et sur votre appareil.…

25. Sécurité de la table de cuissonp. 18
26. ENTRETIEN ET RÉPARATION DE LA TABLE DE CUISSONp. 21

    Nettoyage général IMPORTANT : Avant le nettoyage, s’assurer que toutes les commandes sont désactivées et que le four est froid. Toujours suivre les…

27. Nettoyage généralp. 21

    IMPORTANT : Avant le nettoyage, s’assurer que toutes les commandes sont désactivées et que le four est froid. Toujours suivre les instructions figurant sur les…

28. INSTRUCTIONS D’INSTALLATIONp. 22
29. SPÉCIFICATIONSp. 22

    Outils et pièces Rassembler les outils et pièces nécessaires avant d’entreprendre l’installation. Outils nécessaires n Ruban à mesurer n Tournevis n Clé mixte…

30. Outils et piècesp. 22

    Rassembler les outils et pièces nécessaires avant d’entreprendre l’installation. Outils nécessaires n Ruban à mesurer n Tournevis n Clé mixte de 15/16 po (24…

Other documents for this model

• KitchenAid Commercial Style Dual Fuel Range (KFDS936SSS) installation instructions
• KitchenAid 30 In. Stainless Steel Gas Double Oven Convection Range (KFGD500ESS) installation instructions
• KitchenAid 4.1 Cu. Ft. 4 Element Induction Commercial Style Range (KFIS930SBE) installation instructions
• KitchenAid 4.1 Cu. Ft. Commercial Style Gas Range (KFGS930SBE) installation instructions
• KitchenAid 5 Cu. Ft. Freestanding Gas Range (KFGS530SPS) installation instructions
• KitchenAid 5 Cu. Ft. Gas Range (KFGS330TPS) installation instructions
• KitchenAid 5 Cu. Ft. Slide (KSGS330SPS) installation instructions
• KitchenAid 6.5 Cu. Ft. 5 Burner Gas Convection Slide (KSGS730TPS) installation instructions
• KitchenAid 6 Burner Gas Commercial Style Rangetop 36 Inch Wide (KCGK936TSS) installation instructions
• KitchenAid 7.1 Cu. Ft. 5 Burner Dual Fuel Convection Slide (KSDS730TPS) installation instructions